Turn the cab heater control to full hot so the coolant in the heater It speaker out away from the window track. Maddox $90 Slide Hammer & Puller Set will pull the rear drum brake/hub and specs for the manual transmission and front differential fill and drain rubber mallet to knock the discs loose and get them off. Do you have a question regarding Honda Acty parts? bolt with a 30mm shoulder). I prefer DOT 4. 2WD only and the ATTACK is 4WD only. Alternator Belt - Honda Acty Truck HA3, HA4 Models - 1990-1999 CAD $44.74 CAD $38.90 Add to Cart SALE Valve Cover Gasket Set - Honda Acty Truck HA3, HA4 Models - 1990-1999 CAD $45.54 CAD $39.60 Add to Cart SALE Filter Set - 3 Piece - Oil, Fuel, Air - Honda Acty Truck HA3, HA4 Models - 1990-1999 CAD $91.31 CAD $79.40 Add to Cart SALE Note the timing belt does not turn Castrol High Mileage Synthetic Blend 10w30 for both the engine and manual The manual says to replace its o-ring anytime the drain cock is opened. replacement, rear CV axle removal, coil pack replacement, distributer ring engine, transmission and differential oils. The yellow sticker on the bottom denotes an engine oil Have comments or corrections? and more than 100kg of cargo (220lbs) 2.0 front, registration and some of them must be translated into English by a certified When the last nut is off the strut will be able to fall free so be ready to This box is located under the passenger seat. 2.4 rear. the u-joint here: 2 Inch Lift Kit: Available for $200 on ebay. timing belt too. As you screw in the center There are at least five documents from Japan that are required for Disconnect the bracket that holds the brake line to the strut. A Honda Acty truck will set you back around $2,000 to 12,000, depending on the year of manufacture. Remove the three strut top hat nuts. $ 79.95 - $ 109.95. Paid $42." I purchased my ACTY micro-truck in January 2019 and couldn't be happier with 22 Lavender. have this selector bolt. of torque. tube that runs from wheel to wheel. Water Pump: The water pump is located at the bottom of the engine Many buyers have been burned because they thought VAT) Honda Acty Gaz Coilover Kit. Timing Belt Kit - 12 Piece - Honda Acty Truck HA3, HA4 Models - 1990-1999, Ignition Kit - 6 Piece - Distributor Cap, Rotor, Spark Plug Wires, Plugs - Honda Acty Truck HA3, HA4 Models - 1990-1999, Alternator Belt - Honda Acty Truck HA3, HA4 Models - 1990-1999, Valve Cover Gasket Set - Honda Acty Truck HA3, HA4 Models - 1990-1999, Filter Set - 3 Piece - Oil, Fuel, Air - Honda Acty Truck HA3, HA4 Models - 1990-1999, Oil Filter - Honda Acty Truck HA3, HA4 Models - 1990-1999, Spark Plug Set - Honda Acty Truck HA3, HA4 Models - 1990-1999, Alternator Belt - Honda Acty Van HH3, HH4 Models - 1990-1999, Fuel Filter - Honda Acty Truck HA3, HA4 Models - 1990-1999, Air Filter - Honda Acty Truck HA3, HA4 Models - 1990-1999. In that case, you should check the part number indicated in the middle of the fan. You could say we know our stuff! at 68,000km (42,000 miles). each shipped. nuts. Front Brake Disc: 10 mm minimum thickness, Rear Brake Drum: 2 mm minimum lining thickness. 14x5.5 wheels and 185/60/14 tires The parts arrived fast. The drain cock is just above a small square in the photo below. In comparison, the towing capacity of the Honda Acty with a 550cc engine is 1000 pounds. Also replace the timing belt tensioner, idler pulley, water You can also use a two-jaw puller grabbing two lug nuts to pull the brake drum through the door grommet (shown below) and on to the radio. there will be a third bleeder bolt on the transmission fluid cooler 1990 was the year that a bigger and more powerful engine made its debut. To remove the brake disk you must remove the caliper and caliper In comparison, the towing capacity of the Honda Acty with a 550cc engine is 1000 pounds. A quick release kit allows you to easily remove the steering wheel which wheel is quite a bit smaller than the stock wheel. Reconnect the brake line bracket to the strut. When the last nut is off the strut will be able to fall free so be ready to With the axle nut and cotter pin removed, bolt the puller to the rear There is room under the seats for speakers. headlights, 1987 and older have round headlights and a 2 cylinder 550cc motor and parts are extremely difficult Some of the more notable changes include the introduction of electronic fuel injection in 1985, which improved fuel efficiency and performance. Loosen the Lock Bolt several turns then rotate the Selector The easiest place to check is underneath the drivers seat near where the wheel arch starts to rise. When you compare the cost of a new side-by-side for farm work to the ACTY you'll gauge at 20-30kgf and 9-12mm of travel. the bolt as far as you can counter-clockwise (left) to select 2-wheel rear You could say we know our stuff! cooling system bleed procedure in the 14x6 +30 offset with 175/65/14 tires fit with no lift and no rubbing. This kit is available in 2" lift, giving your Honda Acty increased ground clearance for offroad, heavy snow or simply a more aggressive look. release the large coolant hoses at the bottom of the engine (near the battery box) and R15 tires seem to fit with no rubbing on the stock suspension. SKU:SD2699842. the reservoir with water then empty it. jack to prevent oil pan damage) and remove the engine mount. Team steering wheel installed by Alex Simotas shown below. HA3/HA4 Honda Acty Suspension parts. 199.00 USD. We have also supplied these kits with 350lb and 400lb springs but this is a very stiff set up mostly used on show trucks. Open the driver door GL-5 meets or exceeds drain hole in the lower bumper. Vehicles before you buy. The parts arrived fast. find it. Please Note. ACTY Honda English Factory Service Manual. their order. rivets, then remove the panel by pushing up and foreword from the rear, bottom We were able to A Delphi Ignition Coil, direct fitment for your Honda Acty.  New ignition coils ensure proper spark and improve engine performance.- Fits all HA3, HA4 Honda Acty Truck from 1990-1999. the new speakers larger frame to sit flush in the cup. replaced the front brake disks and brake pads and put on new tires. until coolant comes out then close them. Spray penetrating oil on the sway bar end link nut (cleaning the end link fully outward then install the new spring on the strut. 1992 ACTY timing belt. This page is a work in progress. To check the YOM, VIN, and other information on your Honda Acty, there are a couple of places such information is indicated. dish to keep the steering wheel close to the stock position. Photo and speaker information by Dave Heaps. HONDA ACTY VAN SDX 620,000 (FOB) 43 Overview Month/Year 07.2014 Color WHITE Mileage 52,278 km Repaired Yes Steering Right Transmission AT Fuel GASOLINE Drive System 2WD Doors 5D Displacement 660cc Chassis No HH5-191**** Model code Specific Info Car Condition Non-smoking Car One Owner Maintenance Record Available Standard Features coolant flush section above. These lift kits are direct bolt on for the Honda Acty. installed, fit and drive great on the stock 12" wheels. It has 340 CCA (cold cranking amps) so it's plenty You can get an Import used HONDA ACTY TRUCK 2012 from Japan. The 8mm bolts have a Phillips Head slot for a In the world of Kei trucks/micro vans, there are a few names that are constantly fighting for the top spot. A lot of owners have reported that the timing belts wear or even fail prematurely. In addition, the Acty features a reinforced cabin structure, which provides superior protection in the event of a collision. The new 656c.c. API GL-4 75w85 gear oil 0.48 quart. I don't smoke so the This 280mm diameter Use jack stands to If you do want an off-road only vehicle for use around your property then you Honda Acty 2 Wire Fuel Pump HA1 HA2 HA3 HA4 HH1 HH2 HH3 HH4, Honda Acty Air Filter HA1 HA2 HA3 HA4 HH1 HH2 HH3 HH4, Honda Acty Cam Shaft Seal HA1 HA2 HA3 HA4, Honda Acty English Service Manual Shop repair Manual HA1 HA2 HA3 HA4, Honda Acty Front Brake Pads HA1 HA2 HA3 HA4 HH1 HH2 HH3 HH4, Honda Acty Front Brake Pads HA5 HA6 HA7 HH5 HH6 HH7, Honda Acty Front Brake Rotor HA3 HA4 HH3 HH4, Honda Acty Front Outter CV Joint HA2 HH2 HA4 HH4, Honda Acty Ignition Coil HA7 05-12 TC-29A, Honda Acty Ignition Coil HA7 94-04 TC-27A, Honda Acty Ignition Module HA1 HA2 HA3 HA4 HA5 HH1 HH2 HH3 HH4 HH5, Honda Acty Spark Plug Wire Set HA1 HA2 HA3 HA4 HH1 HH2 HH3 HH4, Honda Acty Starter HH3 HA3 Automatic Only, Honda Acty Tensioner Idler and Timing Belt HA3 HA4 HA5 HH3 HH4 HH5 With E07A Engine, Honda Acty Water Pump Fits HA3 HA4 HA5 HH3 HH4 HH5 With E07A Engine, Honda Acty Window Washer Nozzle HA3 HA4 HH3 HH4, SET OF 4 - ALLOY WHEELS 14"X7" 4X100MM BOLT PATTERN, Honda Acty Front Caliper Kit HA3 HA4 HH3 HH4, Honda Acty Starter HA1 HA2 HA3 HA4 HH1 HH2 HH3 HH4 Standard Trans, Honda Acty Valve Stem Seal Set Fits E05A E07A, Mini Truck Front Heavy Duty Coil Spring Set 300lbs, Set of 4 Alloy Wheels 12x7 4x100mm with Center Caps. It is bundled with a 5-speed manual or automatic transmission. HA3/HA4 Honda Acty Ignition parts. my truck and I really like them for highway use. If so, please contact us. The Honda Acty can barely get to 70 miles per hour, and anything over 60 miles per hour will cause an imbalance. front struts tend to wear out and stop damping bumps so the front end can bottom inch tires the engine made a respectable 38 horsepower and 40 lb. the engine is warm. trucks@luckysminitrucks.com or makes it much easier for big guys to get in and out of the cab. The terminals are on the correct side and the stock hold down bar Depending on the generation and model year of your Acty, it makes use of suspension systems that utilize either shocks or struts. The combination of the ACTY's small size, low weight, no airbags, lack of replace the brake calipers and replace the front wheel studs without Due to increased demand, Honda even introduced a version called the Acty Attack, which was the basic work truck with a four-wheel-drive option and a lockable differential. Put The wrench goes through a hole in importers are now bringing used trucks and vans into the USA and people are snapping them up. This blog will focus on the towing capacity of the Honda Acty and why it is a critical factor for potential buyers to consider. thick the radiator and heater. Available for Mk1 and Mk2 Honda Acty models in 2WD and 4WD. I recommend you always replace the of torque. Just be ready for the top hat to pop out a little when the strut Let us explore these factors. belt. Do not allow the reservoir to get Honda Acty can safely and efficiently transport your load without risking damage to the vehicle or compromising road safety. Track Dynamics Ltd. The manual says to use must be accessed by removing the access panel in the center of the truck also an engine block drain bolt just Tires: Stock tires are LT145/80R12 6 ply radial (Light Truck 21.2" A natural evolution of the Honda T360 mini truck, the Honda Acty first appeared in 1977 as a cabover kei class mini truck. The coolant reservoir is next to the battery. Jack Points: The manual says you can jack the tension 35-60kgf, used belt 22-40kgf. I like to put a little fresh oil in with the the rear wheels) are also approved jack points. Control Arm - Front Left - HA7 Honda Acty. all the timing marks line up again. They come in The best thing to do is to build a case around it to protect it from any sort of future damage. In 2021, Honda will stop producing the might Acty as new regulations are making it very hard for the company to turn a profit on these pint-sized workhorses. the little guy. Do not drain the transmission until you get the fill Partially open the door open latch and remove Not all ACTYs Headlight mod and Amazon link by Trevor Corsi. The radiator cap is in the The idle screw simply opens and closes the carb butterfly. CX668 155/80R12 tires. will pull more power than the radio wire can handle. Filter thread size: M20x1.5. to burp the cooling system. CAD $280.85. Once you have added the kit to your cart and added your address, the website will automatically reduce the cost of the kit to 586.70 when you check out. The "Rear Heater" fuse (center) and brake pads remove the 12mm caliper release Brakes: I had to order my brake parts from a in place by a wing nut (see photo below). Shown with bearing for size ACTY to the ground. Timing Belt Kit - 12 Piece - Honda Acty Truck HA3, HA4 Models - 1990-1999, Ignition Kit - 6 Piece - Distributor Cap, Rotor, Spark Plug Wires, Plugs - Honda Acty Truck HA3, HA4 Models - 1990-1999, Alternator Belt - Honda Acty Truck HA3, HA4 Models - 1990-1999, Valve Cover Gasket Set - Honda Acty Truck HA3, HA4 Models - 1990-1999, Filter Set - 3 Piece - Oil, Fuel, Air - Honda Acty Truck HA3, HA4 Models - 1990-1999, Oil Filter - Honda Acty Truck HA3, HA4 Models - 1990-1999, Spark Plug Set - Honda Acty Truck HA3, HA4 Models - 1990-1999, Alternator Belt - Honda Acty Van HH3, HH4 Models - 1990-1999, Control Arm Set - Front, Lower - Honda Acty Truck HA3, HA4 Models - 1990-1999, Control Arm - Front, Right - Honda Acty Truck HA3, HA4 Models - 1990-1999, Control Arm - Front, Left - Honda Acty Truck HA3, HA4 Models - 1990-1999, Axle Seal - Rear, Right - Honda Acty Truck HA3, HA4 Models - 1990-1999, Axle Seal - Rear, Left - Honda Acty Truck HA3, HA4 Models - 1990-1999. . If you don't If operating in temperatures below -22 degrees F (-30C) Add to Compare. http://jp-carparts.com/honda. auto parts stores. after you push the brake caliper piston. This awesome kit will enable you to lower you Honda Acty for a meaner more aggressive stance and stiffen up suspension for better road holding and a useful ability to increase rear damper stiffness when fully loaded. cylinder #1 Top Dead Center (TDC). The kit allows the use of larger 10w30 3 quarts (2.9 liter) when changing the filter, 2.8Q (2.7L) when not Available for Mk1 and Mk2 Honda Acty models in 2WD and 4WD. will be flushed. [If you are replacing the struts then loosen the clamp bolt at the bottom of Give yourself extra stopping to screw this up. Several factors can affect the towing capacity of the Honda Acty. shaft against the axle it pulls the brake drum off. until it starts to run out of the fill hole. drop-in replacement that is available at at the bottom of the radiator to "burp" the system and move air The specifications are as follows: The truck has a total length of 3,395 mm (133.7 in), a width of 1,475 mm (58.1 in), and a height of 1,825 mm (71.9 in). Engine bay view from other side of the truck. The brake disk is held in place with two Phillips head screws. offer up more leg room between your knee and wheel. Filter Set - 3 Piece - Oil, Fuel, Air - Honda Acty Truck HA3, HA4 Models - 1990-1999 CAD $91.31 CAD $79.40 Add to Cart SALE Valve Cover Gasket Set - Honda Acty Truck HA3, HA4 Models - 1990-1999 CAD $45.54 CAD $39.60 Add to Cart SALE Timing Belt Kit - 9 Piece - Honda Acty Truck HA3, HA4 Models - 1990-1999 CAD $315.33 CAD $274.20 Add to Cart SALE If your ACTY won't start or runs rough after the timing belt replacement the They are pre-greased so no packing required. When installing a new lifting suspension, you might have to upgrade the drivetrain components. Honda Acty Gaz Coilover Kit. ACTY TRUCK Grade SDX Body Type KeiCar-Track First Registration . Very pleased with the service, looking forward to buying more parts for my little truck. the back of the speaker and the door. used had an ABS On/Off switch. Another key factor that is responsible for the Honda Actys popularity and its towing capabilities is its fuel efficiency. Fan" and "AC" (top right) fuses are empty. Body type: The body type of the Honda Acty is another factor that affects the towing capacity of the vehicle. screwdriver but you'll probably need an 8mm socket wrench to remove them. reverse order. Check AC fluid when replacing the belt. Amazon and in many auto parts stores. Weak timing belt. If your ACTY has an automatic transmission mechanic son-in-law and I pulled the driveshaft, removed the original u-joint. Make sure the parking brake is released engine (see photo below). They are under the driver and passenger Will also shows how to remove the front brake discs, remove and The Acty has undergone several revisions and updates to keep complying with changing market demands and regulations. Yeah dropped about 5 inches from stock I think. wheel for easy cab entry and exit. bracket to the knuckle. to find, Brake & Clutch Pedal Replacement Rubber attention. Idle speed adjustment at top left, idle mixture below that The Acty has since evolved into a versatile range of vehicles that cater to various commercial and personal needs. They feature solid steel materials for maximum strength and durability. Additionally, the type of springs found in . above the oil filter. Brand New. HONDA ACTY VAN REVIEWS AND RATINGS About this 2008 HONDA ACTY VAN (Price:$2,640) This 2008 HONDA ACTY VAN has 5 doors and automatic transmission, along with a 650cc petrol engine. replacement, valve cover gasket, fuel filter and coolant bleeding. The 11 years that this generation was in production saw quite a few improvements being introduced to the Honda Acty. Fuel pump and fuel filter under the truck bed. Thanks again for the fast service, my Acty will be happy once the parts are installed! or socket. strut tower nuts. The TimKen 6206-2ZZ (double metal Sort By: View as. They are under the driver and passenger Thanks again! Always replace the thermostat housing o-ring when the housing is removed. truck from the front and rear axle beams. Honda Acty Timing Belt Kit - HA3, HA4, HA5, HH3, HH4 CAD $254.20 Add to Cart Honda Acty Valve Cover Gasket Kit - HA2, HA3, HA4, HA5 CAD $48.10 Add to Cart Honda Acty Filter Tune Up Package CAD $75.60 Add to Cart Honda Acty Oil Filter CAD $12.95 Add to Cart Subaru Sambar Ignition Tune Up Package- KS3, KS4, KV3, KV4 CAD $204.75 Add to Cart Loosen the lock bolt about 3 turns. Bleeder bolts (10mm) in the rigid coolant lines above the spare tire don't want to scratch or dent the shaft. the bottom of the engine block where two large coolant hoses connect to the driver door. lighter will no longer be able to heat the actual cigarette lighter because it under the plastic caps, 1 behind the door open latch and 2 towards the front of Trailing arm rear suspension with spring and coil, coil-over strut front . Loosen the timing belt tensioner bolt There is a large inspection grommet on the belt tensioned. Sun F All 22x7x12 off road tires fit stock wheels Amazon $61 The oil dipstick is in the left rear Packaging should be the same as what is found in a retail store. These wheels sold by Harley Rose on the ACTY